• 新聞資訊

    首頁>>新聞資訊 >

    加長臂更換液壓油時要注意些什么?

    日期:2018-09-27   來源:http://www.xjltc.com/
    1、購買整車液壓系統用的油。(液壓油箱容積的2。5倍),濾芯,洗油,3公斤面粉,繩子,封閉液壓油管的油堵,(按換油的挖掘機上的油管配制)一臺汽泵和大小空油桶等。準備一臺正常的挖掘機。將換油的挖掘機動臂抬升到較高點,斗桿及鏟斗收到內點后發動機熄滅(動臂缸,斗桿缸和鏟斗缸的缸桿全部伸出到頂點)。
    1, buy the oil used in vehicle hydraulic system. (2 of the volume of the hydraulic tank. Five times), filter element, washing oil, 3 kilograms of flour, rope, oil plug of closed hydraulic tubing, (according to the tubing on the oil-changing excavator), a steam pump and empty oil drum, etc. Prepare a normal excavator. The boom of the oil-changing excavator is lifted to a higher point, and the engine is extinguished when the bucket bar and bucket receive the interior point (the boom cylinder, the bucket bar cylinder and the bucket cylinder all extend to the top).
    2、液壓油箱的清洗:將箱內的液壓油全部放出,撤出液壓濾芯,把泵和油箱之間的管路從泵的接口處拆開,放出管路內的油液。用洗油沖洗液壓油箱和管路。用醫用沙布把液壓油箱內部擦凈。將面粉揉和到能拉伸面的程度分成三份,用面團分三次粘干凈液壓油箱的里面尤其是油箱的邊角處和濾芯筒。液壓油箱和濾芯筒內必須徹底清理干凈。更換新的液壓濾芯,上好蓋板。
    2. Hydraulic tank cleaning: all the hydraulic oil in the tank is discharged, the hydraulic filter element is withdrawn, the pipeline between the pump and the tank is removed from the pump interface, and the oil in the pipeline is discharged. Wash the hydraulic oil tank and line with the wash oil. Clean the inside of the hydraulic tank with medical sand cloth. Mix the flour into three parts until the surface is stretchable. Use the dough three times to clean the inside of the hydraulic tank, especially the corner of the tank and the filter cartridge. The hydraulic oil tank and filter cartridge must be thoroughly cleaned up. Replace the new hydraulic filter element with a good cover.
    加長臂挖掘機出租
    挖掘機加長臂液壓油更換完成后也要記得保養:
    Remember to maintain the excavator plus long arm hydraulic oil after completing the replacement.
    1、要保持液壓油的清潔。
    1, keep the hydraulic oil clean.
    液壓油必須放在清潔的位置,換油的時候要用配備細格濾網的清潔漏斗將油從容器倒入油箱,如果液壓油中含有雜質,將會卡住閥、擦傷泵、阻塞油口,造成機器故障。
    Hydraulic oil must be placed in a clean position. When changing oil, the oil should be poured from the container into the tank with a clean funnel equipped with fine mesh filter. If the hydraulic oil contains impurities, it will jam the valve, scratch the pump and block the oil port, causing machine failure.
    2、要保持系統的清潔。
    2, keep the system clean.
    定期更換液壓油和液壓油的過濾器。因為液壓油中有很多添加劑,這些添加劑的本來作用是防止液壓油變質,但是5000小時后就會過期,這時候就應該更換新的液壓油了。除了換油之外還應該定期排除油箱中的水和沉淀物,如果油箱中有沉淀物,而不清洗,更換液壓油是沒有作用的。
    Regular replacement of hydraulic oil and hydraulic oil filter. Because there are a lot of additives in the hydraulic oil, the original purpose of these additives is to prevent deterioration of the hydraulic oil, but after 5000 hours will expire, this time it should be replaced by a new hydraulic oil. In addition to oil change, water and sediment in the tank should also be regularly removed. If there is sediment in the tank, but not cleaned, the replacement of hydraulic oil is not effective.
    3、要保持工作區域的清潔。
    3, keep the work area clean.
    本文由加長臂挖掘機租賃整理發布,您是不是對這些內容有所了解了呢?更多的內容請點擊:http://www.xjltc.com我們會有更多精彩內容等你查看。
    This article is published by Lengthened Arm Excavator Rental. Do you know something about it? For more information, please click: http://www.xjltc.com. We will have more exciting content for you to see.

    【本站圖片均由網站所有方提供,部分圖片來源于網絡,如無意中侵犯了某媒體或個人的知識產權,請來信或來電告之,本網站將立即刪除?!?/p> 在线观看国产精品乱码APP,国产精品国产亚洲AV,暗呦交小U女国产精品视频,国产精品对白刺激久久久